PDA

View Full Version : rhino problems



r6eric
08-14-2008, 08:47 PM
hello all i have a problem with my rhino last year of carb. after it get warmed up and i come to a stop it backfire and dies we thought it could be old gas so cleaned out lines,carb,fuel pump no luck could it need a valve adjustment i only have 16 hours on it.
thanks eric

ffjosh
08-14-2008, 09:05 PM
If it was vavles it should start hard. (atleast most the time)

Check the spark when hot. Could be a faulty pick up coil, ignition coil, CDI ect.

Does it start right back up after it dies?

r6eric
08-15-2008, 05:14 AM
yes starts right back up with no problem put it in gear give it gas pop and dies.

ffjosh
08-15-2008, 07:22 AM
does it rev up in nutreaul fine?

utvfab
08-15-2008, 07:14 PM
I know it sounds strange but it is most likley your fuel filter. Scrap the stock one and get one from a parts store, less than $5.00. It should solve your problem.

plkracer
08-15-2008, 09:09 PM
Rhino's had a problem with their vaccum pump too. I've known of a few which took a dump. Open it up and look at the diaphragm.

r6eric
08-15-2008, 09:21 PM
took time to really find out whats happening after it warms up if i give it gas to about 2thousand rpm it backfire throught the carb until i give it gas.on higher rpm it runs fine. also took it out for a drive and when i come to a stop it will backfire or pop and wants to die till i give it gas but then i go to another stop and it will run fine.cleaned carb,replace fuel filterand also replaced spark plug.thanks guys for your help.

masterfabr
08-16-2008, 08:18 AM
Only 16 hours on it? Is it out of warranty?

Joe Llamahead
08-17-2008, 01:24 AM
Probably running too lean, try running the next size up primary jet and see if things improve.

r6eric
08-19-2008, 04:54 AM
you guys wouldnt believe what it was spark plug change it out problem went away thanks for input. eric

Bugpac
08-19-2008, 04:58 AM
what did the spark plug look like? was it real black or whitish?

r6eric
08-23-2008, 11:12 PM
sorry bugpac didnt write u early working on rorty r6 sparkplug was whitish color.